EFEK BLENDING BAHAN BAKAR TERBARUKAN BUTANOL 5% PADA PERTAMAX TERHADAP PERFORMA MESIN BENSIN EFI 150 CC

Sigit Setijo Budi; Firman Lukman Sanjaya; Faqih Fatkhurrozak; Syarifudin -; Agus Hut Riyono

doi:10.30591/polektro.v13i1.6590

EFEK BLENDING BAHAN BAKAR TERBARUKAN BUTANOL 5% PADA PERTAMAX TERHADAP PERFORMA MESIN BENSIN EFI 150 CC

Sigit Setijo Budi, Firman Lukman Sanjaya, Faqih Fatkhurrozak, Syarifudin -, Agus Hut Riyono

Abstract

Butanol is an alternative energy that is being developed to overcome the energy crisis. This is because butanol has a high Octane number and oxygen content so it can optimize engine performance. This research was carried out to determine the impact of adding butanol to Pertamax on gasoline engine performance. The engine used is a 150 cc EFI petrol engine. The fuel uses Pertamax with butanol additive. Testing uses speed variations of 1000 – 3000 rpm. Test results: The performance of the 150 cc EFI petrol engine using the Pertamax-butanol mixture (P95B5) has increased compared to using pure Pertamax fuel (P100). This can be seen from the increase in torque and power with Pertamax-butanol fuel (P95B5) of 3.57 N.m and 1.12 kW, the highest increase at rpm 3000. Engine fuel consumption decreased when butanol was added compared to pure Pertamax (P100). The lowest fuel consumption occurred with Pertamax-butanol (P95B5) fuel at 0.21 ml/s when the engine speed was 100 rpm. Meanwhile, the highest fuel consumption occurred in Pertamax fuel (P100) at 0.62 ml/s when the engine speed was 3000 rpm

Keywords

Butanol, pertamax, performa, mesin bensin

Full Text:

References

H. C. Zhao, S. B. Wang, T. Z. Yu, and P. Sun, “Study on combustion and emissions characteristics of acetone-butanol-Ethanol(ABE)/gasoline premixed fuel in CISI engines,” Case Stud. Therm. Eng., vol. 51, no. September, p. 103591, 2023, doi: 10.1016/j.csite.2023.103591.

F. L. Sanjaya, M. K. Usman, F. Fatkhurrozak, S. Syarifudin, and A. B. Hendrawan, “Efek Pencampuran Butanol dan Diethyl Ether (DEE) Pada Pertalite Terhadap Torsi, Daya dan Brake Spesific Fuel Consumpsion Mesin Bensin 160cc,” Infotekmesin, vol. 14, no. 2, pp. 280–284, 2023, doi: 10.35970/infotekmesin.v14i2.1906.

F. L. Sanjaya, S. Syarifudin, and F. Fatkhurrozak, “Efek Penambahan Butanol Terhadap Emisi dan Temperatur Gas Buang Mesin Bensin EFI Menggunakan EGR,” Infotekmesin, vol. 13, no. 1, pp. 8–12, 2022, doi: 10.35970/infotekmesin.v13i1.677.

Z. Tian, X. Zhen, Y. Wang, D. Liu, and X. Li, “Combustion and emission characteristics of n-butanol-gasoline blends in SI direct injection gasoline engine,” Renew. Energy, vol. 146, pp. 267–279, 2020, doi: 10.1016/j.renene.2019.06.041.

I. E. Yousif and A. M. Saleh, “Butanol-gasoline blends impact on performance and exhaust emissions of a four stroke spark ignition engine,” Case Stud. Therm. Eng., vol. 41, no. September 2022, p. 102612, 2023, doi: 10.1016/j.csite.2022.102612.

A. Verma, N. S. Dugala, and S. Singh, “Experimental investigations on the performance of SI engine with Ethanol-Premium gasoline blends,” Mater. Today Proc., vol. 48, no. xxxx, pp. 1224–1231, 2021, doi: 10.1016/j.matpr.2021.08.255.

F. L. Sanjaya, Syaiful, and D. N. Sinaga, “Effect of Premium-Butanol Blends on Fuel Consumption and Emissions on Gasoline Engine with Cold EGR System,” J. Phys. Conf. Ser., vol. 1373, no. 1, pp. 11–17, 2019, doi: 10.1088/1742-6596/1373/1/012019.

G. Setyono, D. Khusna, N. Kholili, L. P. Sanjaya, and F. G. A. Putra, “Effect of Butanol-Gasoline Blend Toward Performance Matic-Transmission Applied in Single Cylinder Capacity Engine,” Infotekmesin, vol. 14, no. 1, pp. 28–34, 2023, doi: 10.35970/infotekmesin.v14i1.1629.

S. Syarifudin and S. Syaiful, “Pengaruh Penggunaan Energi Terbarukan Butanol Terhadap Penurunan Emisi Jelaga Mesin Diesel Injeksi Langsung Berbahan Bakar Biodiesel Campuran Solar Dan Jatropa,” Infotekmesin, vol. 10, no. 1, pp. 18–22, 2019, doi: 10.35970/infotekmesin.v10i1.20.

Z. Guo et al., “Experimental study on combustion and emissions of an SI engine with gasoline port injection and acetone-butanol-ethanol (ABE) direct injection,” Fuel, vol. 284, no. July 2020, p. 119037, 2021, doi: 10.1016/j.fuel.2020.119037.

G. Setyono, D. Khusna, N. Kholili, L. Putra Sanjaya, and F. G. Argil Putra, “Investigation of Exhaust Emissions Combustion Characteristics in Single Spark Ignition-Engine Matic with Butanol-Gasoline Mixture,” Infotekmesin, vol. 14, no. 2, pp. 273–279, 2023, doi: 10.35970/infotekmesin.v14i2.1903.

E. Yohana and F. Fatkhurrozak, “Korelasi Konsentrasi Etanol 5 % Pada Bahan Bakar Gasolin Terhadap Performa , dan Emisi Gas Buang Mesin Bensin 150cc,” vol. 14, no. 01, pp. 149–154, 2023, doi: 10.35970/infotekmesin.v14i1.1737.

Syarifudin, F. Fatkhurrozak, F. L. Sanjaya, E. Yohana, Syaiful, and A. Wibowo, “The Effect of Ethanol on Brake Torque, Brake Specific Fuel Consumption, Smoke Opacity, and Exhaust Gas Temperature of Diesel Engine 4JB1 Fueled by Diesel-Jatropha Oil,” Automot. Exp., vol. 5, no. 2, pp. 230–237, 2022, doi: 10.31603/ae.6447.

M. Z. Işık, H. Bayındır, B. İscan, and H. Aydın, “The effect of n-butanol additive on low load combustion, performance and emissions of biodiesel-diesel blend in a heavy duty diesel power generator,” J. Energy Inst., vol. 90, no. 2, pp. 174–184, 2017, doi: 10.1016/j.joei.2016.02.006.

F. L. Sanjaya, S. Syaiful, and S. Syarifudin, “Brake spesific fuel consumption, brake thermal efficiensy, dan emisi gas buang mesin bensin EFI dengan sistem EGR berbahan bakar premium dan butanol,” Turbo J. Progr. Stud. Tek. Mesin, vol. 9, no. 2, pp. 170–176, 2020, doi: 10.24127/trb.v9i2.1178.

DOI: https://doi.org/10.30591/polektro.v13i1.6590

Refbacks

There are currently no refbacks.

This work is licensed under a Creative Commons Attribution-NonCommercial 4.0 International License.

----------------------------------------------------------------------------------------------------------------------

Indexed By :

----------------------------------------------------------------------------------------------------------------------

Tim Redaksi POWER ELEKTRONIK : JURNAL ORANG ELEKTRO

Program Studi D3 Teknik Elektro
Politeknik Harapan Bersama Tegal
Jl. Mataram No.09 Pesurungan Lor Kota Tegal

Telp. (0283) 350567

Email :
powerelektronik.ejournal@poltektegal.ac.id

elektropower41@gmail.com

View Visitor Statistic

Power Elektronik : Journal Orang Elektro licensed under a Creative Commons Attribution-NonCommercial 4.0 International License.

Username
Password
Remember me